Page 1 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A P erformance - Based S tandards (PBS ) Vehicle Approval Heavy Vehicle National Law S ection 23 Heavy Vehicle (General) National Regulation S ection 17 This is not an authorisat ion to access the road network. You must comply with the relevant Notice or if required, obtain an access permit. 24 March 2022 Ref No: PBS – V 211212 – VA 10804 – TEFCO TRAILERS (QLD) PTY. LIMITED / Dur – v 1 A This PBS Vehicle Approval modifies any previously issued approval for the vehicle ( s ) listed here in operating under Application N umber V 211212 Applicant d etails Stuart Buck TEFCO TRAILERS (QLD) PTY. LIMITED 24 - 26 Alexandra Pl Murarrie QLD 4172 Operator Dur 43 Croome Lane Albion Park NSW 2527 Application N umber V 211212 Vehicle 3 - axle truck 5 - axle dog 5 - axle dog Load Quarry and Bulk Length (mm) ≤ 36 300 Assessor Saizo Takeuchi Height (mm) ≤ 4300 Page 2 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A Combination matrix For each truck and trailer, the corresponding dimension set number is listed. The dimension set number (e.g. Original ) indicates the maximum allowable payload heights and/or allowable tyre options for the specific combination (refer to payload height operating conditions and approved tyr e options). Additional vehicle units are listed in bold. Truck 1 5KKJBEBG3NPNL9683 Lead Trailer 1 6T9T24R02NADY0001 Rear Trailer 1 6T9T24R02NADY000 2 Trailer Set 1 Lead Trailer 1 Rear Trailer 1 Trailer 1 Truck 1 Original Table 1 , 2 Page 3 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A Table 1 Truck 1 and Trailer Set 1 Mass Limits Level 3 Axle Group Masses Level 3 GML CML HML GML (t) 96.0 Steer (t) 6.5 6.5 6.5 CML (t) 98.0 Drive (t) 16.5 17.0 17.0 HML (t) 102.5 Lead Trailer (t) - 1 st Axle Group 16.5 17.0 17.0 Bridge Assessment Tier 1 Lead Trailer (t) - 2 nd Axle Group 20.0 21.0 22.5 Rear Trailer - 1 st Axle Group 16.5 17.0 17.0 Rear Trailer (t) - 2 nd Axle Group 20.0 21.0 22.5 Table 2 Truck 1 and Trailer Set 1 Queensland CML Mass Limits Level 3 Axle Group Masses Level 3 QLD CML QLD CML (t) 99.0 Steer (t) 6.5 Bridge Assessment Tier 1 Drive (t) 17.0 Lead Trailer (t) - 1 st Axle Group 17.0 Lead Trailer (t) - 2 nd Axle Group 21.0 Rear Trailer - 1 st Axle Group 17.0 Rear Trailer (t) - 2 nd Axle Group 21.0 Page 4 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A Operating conditions The NHVR approves the vehicles listed herein for the level (s) shown in the “Mass Limits” table with the following operating conditions: 1. The total combination mass must not exceed the limits in the “Mass Limits” table. 2. The axle group masses must not exceed the limits in the “Axle Group Masses” table. 3. If the “Mass Limits” table specifies Tier 2 or 3, a bridge assessment is required. 4. Maximum payload heights measured from the ground must not exceed: (m) Heaped payload Water level p ayload Truck 3.433 3.233 Lead Trailer 3.480 3.280 Rear Trailer 3.480 3.280 Heaped payloads are taken to be the same volume of material as water level payloads 5. 6.5 tonne complying steer axle requirements: o an engine that complies with the engine emission standards of Australian Design Rule (ADR) 80/01 (Euro 4) or a later version of ADR 80; and o a front underrun protection device (FUPD) that complies with UN ECE Regulation 93 or ADR 84; and o a cabin that complies with UN ECE Regulation 29. 6. Concessional Mass Limits (CML) requirements: o a National Heavy Vehicle Accreditation Scheme (NHVAS) – Mass Management A ccreditation must be in force for all motor vehicle s listed on this vehicle approval. 7. Higher Mass Limi ts (HML) requirements: o for tandem axles groups, road friendly suspensions. 8. When operating at Level 3, there is a minimum mass requirement for the drive axle group. The mass on the drive axle group must be at least 16% of the total combination mass e.g. at 96 t total combination mass, 96 x 0.16 = 1 5.36 t is required on the drive axle group. This clause does not apply to an unladen vehicle. 9. If overall length exceeds 30m, a “ROAD TRAIN” sign must be displayed at the front and rear of the vehicle 10. If drawbar leng th exceeds 5m, the outermost surface of the drawbar must be fitted with yellow reflective material that complies with Class C material requirements of United National Economic Commission for Europe Regulation No. 104 Uniform provisions concerning the appro val of retro - reflective markings for vehicles of category M, N and O. Page 5 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A Exemptions Heavy Vehicle National Law S ection 24 Heavy Vehicle (General) National Regulation S ection 28 The following table lists exemptions from prescribed vehicle standards that hav e been granted for the vehicle ( s ) in this vehicle approval. Exemptions ADR Rule 43, Clause 6.2.2 (Drawbar length – Trailers) Rule 63, Clause 5.1 (Tow coupling location) HV(MDL)NR Schedule 6, Section 6 (Length – Trailer drawbars) HV(VS)NR Schedule 3, Section 29 (Attachment of couplings and drawbar eyes on road trains) ADR Australian Design Rules HV(MDL)NR Heavy Vehicle (Mass, Dimension and Loading) National Regulation HV(VS)NR Heavy Vehicle (Vehicle Standards) National Regulation Page 6 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A Page 7 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A Detail s of truck(s) or prime mover(s) – Truck 1 Make Western Star Model 4864FXB VIN(s) 5KKJBEBG3NPNL9683 Engine make/ model/ rating Cummi n s ISX e5 (ADR 80/03) Transmission make/ model Eaton Fuller RTLO20918B Differential make/ model/ FD ratio Meritor RT46 - 160GP, FDR = 4.30:1 Suspension make/ model (Steer) Western Star taper leaf 7,250kg Suspension make/ model (Drive) Airliner AL46K - HD (RF2013) Tyres make/ size/ model (Steer) 295/8022.5 Michelin X Multiway 3D XZE Tyres make/ size/ model (Drive) 11R22.5 Michelin X Multi Brakes (Load Proportioning, ABS, ECB, etc.) ABS Tow coupling make/ D rating Conventional automatic pin type coupling, D = 320 kN Wheelbase (mm) 5 690 Vehicle height (Measured from the ground) (mm) 3 233 Number of axles 3 ADR category NC GVM (kg) 27,360 GCM (kg) 106,000 Comments / n otes: Page 8 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A Details of t railer(s) or dolly( s) – Lead Trailer 1 Type 5 - axle dog trailer - tipper Make Tefco Pty Ltd Model Tefco 5 Axle Dog VIN(s) 6T9T24R02NADY0001 Suspension make/ model Front: Hendrickson Intraax AAT230 - 13.5" RH Rear: Hendrickson Intraax AAT230 - 12" RH ( RF2008) Tyres make/ size/ model 11R22.5 BFGoodrich Route Control Drawbar length (mm) 5 591 Coupling make/ D rating Front: Toweye , D = 314 kN Rear: Conventional automatic pin type coupling, D = 320 kN Brakes (Load Proportioning, ABS, ECB, etc.) EBS Wh eelbase (mm) 6 574 Vehicle height (Measured from the ground) (mm) 3 280 Number of axles 5 ADR category TD ATM (kg) 40 ,500 Comments / n otes: Page 9 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A Details of trailer(s) or dolly(s) – Rear Trailer 1 Type 5 - axle dog trailer - tipper Make Tefco Pty Ltd Model Tefco 5 Axle Dog VIN(s) 6T9T24R02NADY000 2 Suspension make/ model Front: Hendrickson Intraax AAT230 - 13.5" RH Rear: Hendrickson Intraax AAT230 - 12" RH (RF2008) Tyres make/ size/ model 11R22.5 BFGoodrich Route Control Drawbar length (mm) 5 591 Coupling make/ D rating Front: Toweye , D = 314 kN Rear: N/A Brakes (Load Proportioning, ABS, ECB, etc.) EBS Wheelbase (mm) 6 574 Vehicle height (Measured from the ground) (mm) 3 280 Number of axles 5 ADR category TD ATM (kg) 40 ,500 Comments/ notes: Page 10 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A Approved tyre options Steer – o non - brand specific 22.5 - inch rim diameter Drive and Trailer – A cell that is denoted by a ‘•’ indicates a permissible combination of drive and trailing unit tyres. Cells that are blank are not permitted. Retread tyres are permitted on the steer axle. Retread tyres are permitted on the drive and trailer axles, provided they are certified by the manufacturer that its performance is equivalent to a new tyre. Tyre load ratings must be appropriate for the axle mass. Tyres listed herein are specific for PBS application number V211212. A different list of tyres will apply for other combination types and different PBS application numbers. Advance GL671A 11R22.5 Aeolus HN06 11R22.5 Aeolus HN08 11R22.5 Aeolus HN266 11R22.5 Austone AT27s 11R22.5 Austyre ST01 11R22.5 BFGoodrich Route Control S 11R22.5 Boto BT168 11R22.5 Boto BT370 11R22.5 Bridgestone 11R22.5 Bridgestone R109 11R22.5 Bridgestone R168 11R22.5 Chao Yang CR926D 11R22.5 Chao Yang CR960A 11R22.5 Continental HSC1 11R22.5 Continental HTR 11R22.5 Continental Hybrid HT3 11R22.5 Doublestar HR169 11R22.5 Doublestar HR268 11R22.5 Dunlop 11R22.5 Durun YTH1 11R22.5 Durun YTH4 11R22.5 Firestone FT469 11R22.5 Firestone T559 11R22.5 GT Radial GT276 11R22.5 General Tire RA 11R22.5 GiTi GAR827 11R22.5 GiTi GT276 11R22.5 Goodride AS678 11R22.5 Goodride CB972 11R22.5 Goodride CR926D 11R22.5 Goodride CR960A 11R22.5 Goodyear 11R22.5 Hankook AH22 11R22.5 Hankook AM06 11R22.5 Hankook TH06 11R22.5 Hankook TH22 11R22.5 Advance GL671A 11R22.5 • Aeolus HN08 11R22.5 • Aeolus HN266 11R22.5 • Boto BT168 11R22.5 • Bridgestone 11R22.5 • Bridgestone 295/80R22.5 • • • • • Bridgestone M866 11R22.5 • Continental HD HYBRID 295/80R22.5 • Continental HDC1 295/80R22.5 • Doublestar HR169 11R22.5 • Doublestar HR268 11R22.5 • Dunlop 11R22.5 • Dunlop 295/80R22.5 • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • Durun YTH1 11R22.5 • Falken BI830 11R22.5 • Falken BI850 11R22.5 • Firestone T559 11R22.5 • Golden Crown AZ126 11R22.5 • • Goodride CM958 295/80R22.5 • • Goodride CM983 11R22.5 • Goodyear 11R22.5 • Goodyear 295/80R22.5 • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • Hankook AH33 295/80R22.5 • TRAILING UNIT TYRES DRIVE TYRES Page 11 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A Approved tyre options Steer – o non - brand specific 22.5 - inch rim diameter Drive and Trailer – A cell that is denoted by a ‘•’ indicates a permissible combination of drive and trailing unit tyres. Cells that are blank are not permitted. Retread tyres are permitted on the steer axle. Re tread tyres are permitted on the drive and trailer axles, provided they are certified by the manufacturer that its performance is equivalent to a new tyre. Tyre load ratings must be appropriate for the axle mass. Tyres listed herein are specific for PBS ap plication number V211212. A different list of tyres will apply for other combination types and different PBS application numbers. Hankook TH31 11R22.5 Hankook TM22 11R22.5 Haulmax ATT101 11R22.5 Haulmax ATT103 11R22.5 Haulmax ATT105 11R22.5 Haulmax ATT202 11R22.5 Hifly HH104 11R22.5 Hifly HH301 11R22.5 Hilo 100 11R22.5 Jinyu JY601 11R22.5 Kumho KRT03 11R22.5 Michelin 11R22.5 Michelin X Multi T 11R22.5 Michelin X Multi T2 11R22.5 NiPon AZ126 11R22.5 O'Green AG168 11R22.5 Remington R628 11R22.5 Remington R628 II 11R22.5 Remington R666 II 11R22.5 Sailun S665 EFT 11R22.5 Sailun S815 11R22.5 Sportrak SP398 11R22.5 Sportrak SP901 11R22.5 Techking TKAM C+ 11R22.5 Techking TKAM II 11R22.5 Toyo M122 11R22.5 Triangle TR666 11R22.5 Triangle TR668 11R22.5 Triangle TR688 11R22.5 Triangle TRS01 11R22.5 Westlake CR926D 11R22.5 Westlake MD738 11R22.5 Windpower HN06 11R22.5 Windpower HN08 11R22.5 Windpower HN266 11R22.5 Windpower WDR23 11R22.5 Windpower WGC08 11R22.5 Windpower WSL06 11R22.5 Yokohama RY588 11R22.5 Advance GL671A 11R22.5 • Aeolus HN08 11R22.5 Aeolus HN266 11R22.5 • Boto BT168 11R22.5 • Bridgestone 11R22.5 • Bridgestone 295/80R22.5 • • • • Bridgestone M866 11R22.5 • Continental HD HYBRID 295/80R22.5 • Continental HDC1 295/80R22.5 • Doublestar HR169 11R22.5 • Doublestar HR268 11R22.5 • Dunlop 11R22.5 • Dunlop 295/80R22.5 • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • Durun YTH1 11R22.5 • Falken BI830 11R22.5 • Falken BI850 11R22.5 Firestone T559 11R22.5 • Golden Crown AZ126 11R22.5 • Goodride CM958 295/80R22.5 • Goodride CM983 11R22.5 • Goodyear 11R22.5 • Goodyear 295/80R22.5 • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • Hankook AH33 295/80R22.5 • TRAILING UNIT TYRES DRIVE TYRES Page 12 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A Approved tyre options Steer – o non - brand specific 22.5 - inch rim diameter Drive and Trailer – A cell that is denoted by a ‘•’ indicates a permissible combination of drive and trailing unit tyres. Cells that are blank are not permitted. Retread tyres are permitted on the steer axle. Retread tyres are permitted on the drive and trailer axles, provided they are cert ified by the manufacturer that its performance is equivalent to a new tyre. Tyre load ratings must be appropriate for the axle mass. Tyres listed herein are specific for PBS application number V211212. A different list of tyres will apply for other combina tion types and different PBS application numbers. Advance GL671A 11R22.5 Aeolus HN06 11R22.5 Aeolus HN08 11R22.5 Aeolus HN266 11R22.5 Austone AT27s 11R22.5 Austyre ST01 11R22.5 BFGoodrich Route Control S 11R22.5 Boto BT168 11R22.5 Boto BT370 11R22.5 Bridgestone 11R22.5 Bridgestone R109 11R22.5 Bridgestone R168 11R22.5 Chao Yang CR926D 11R22.5 Chao Yang CR960A 11R22.5 Continental HSC1 11R22.5 Continental HTR 11R22.5 Continental Hybrid HT3 11R22.5 Doublestar HR169 11R22.5 Doublestar HR268 11R22.5 Dunlop 11R22.5 Durun YTH1 11R22.5 Durun YTH4 11R22.5 Firestone FT469 11R22.5 Firestone T559 11R22.5 GT Radial GT276 11R22.5 General Tire RA 11R22.5 GiTi GAR827 11R22.5 GiTi GT276 11R22.5 Goodride AS678 11R22.5 Goodride CB972 11R22.5 Goodride CR926D 11R22.5 Goodride CR960A 11R22.5 Goodyear 11R22.5 Hankook AH22 11R22.5 Hankook AM06 11R22.5 Hankook TH06 11R22.5 Hankook TH22 11R22.5 Hankook AL10 295/80R22.5 • Hankook DL10 295/80R22.5 • Haulmax ATT101 11R22.5 • Haulmax ATT105 11R22.5 • Haulmax ATT202 11R22.5 • Hifly HH312 11R22.5 • Jinyu JY601 11R22.5 • Maxxis UR200 295/80R22.5 • Michelin 11R22.5 • Michelin 295/80R22.5 • • • • • Sailun S665 EFT 11R22.5 • Sportrak SP901 11R22.5 • Techking SuperDM 11R22.5 • Techking TKAM C+ 11R22.5 • Techking TKAM II 11R22.5 • Techking TKAM II 295/80R22.5 • Toyo M122 11R22.5 • Triangle TR666 11R22.5 • Triangle TR668 11R22.5 • • • • • • • • • Triangle TR688 11R22.5 • • • • • • • • • Triangle TRS01 11R22.5 • Windpower HN08 11R22.5 • Windpower HN266 11R22.5 • Windpower WDR23 11R22.5 • Windpower WGC08 11R22.5 • DRIVE TYRES TRAILING UNIT TYRES Page 13 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A Approved tyre options Steer – o non - brand specific 22.5 - inch rim diameter Drive and Trailer – A cell that is denoted by a ‘•’ indicates a permissible combination of drive and trailing unit tyres. Cells that are blank are not permitted. Retread tyres are permitted on the steer axle. Retread tyres are permitted on the drive and trailer axles, provided they are certified by the manufacturer that its performance is equivalent to a new tyre. Tyre load ratings must be appropriate for the axle mass. Tyres listed herein are specific for PBS application number V211212. A different list of tyres will apply for other combination types and different PBS application numbers. Hankook TH31 11R22.5 Hankook TM22 11R22.5 Haulmax ATT101 11R22.5 Haulmax ATT103 11R22.5 Haulmax ATT105 11R22.5 Haulmax ATT202 11R22.5 Hifly HH104 11R22.5 Hifly HH301 11R22.5 Hilo 100 11R22.5 Jinyu JY601 11R22.5 Kumho KRT03 11R22.5 Michelin 11R22.5 Michelin X Multi T 11R22.5 Michelin X Multi T2 11R22.5 NiPon AZ126 11R22.5 O'Green AG168 11R22.5 Remington R628 11R22.5 Remington R628 II 11R22.5 Remington R666 II 11R22.5 Sailun S665 EFT 11R22.5 Sailun S815 11R22.5 Sportrak SP398 11R22.5 Sportrak SP901 11R22.5 Techking TKAM C+ 11R22.5 Techking TKAM II 11R22.5 Toyo M122 11R22.5 Triangle TR666 11R22.5 Triangle TR668 11R22.5 Triangle TR688 11R22.5 Triangle TRS01 11R22.5 Westlake CR926D 11R22.5 Westlake MD738 11R22.5 Windpower HN06 11R22.5 Windpower HN08 11R22.5 Windpower HN266 11R22.5 Windpower WDR23 11R22.5 Windpower WGC08 11R22.5 Windpower WSL06 11R22.5 Yokohama RY588 11R22.5 Hankook AL10 295/80R22.5 • Hankook DL10 295/80R22.5 • Haulmax ATT101 11R22.5 • Haulmax ATT105 11R22.5 • Haulmax ATT202 11R22.5 Hifly HH312 11R22.5 Jinyu JY601 11R22.5 • Maxxis UR200 295/80R22.5 • Michelin 11R22.5 • Michelin 295/80R22.5 • • • • Sailun S665 EFT 11R22.5 • Sportrak SP901 11R22.5 • Techking SuperDM 11R22.5 • Techking TKAM C+ 11R22.5 • Techking TKAM II 11R22.5 Techking TKAM II 295/80R22.5 • Toyo M122 11R22.5 • Triangle TR666 11R22.5 • Triangle TR668 11R22.5 • • • • • • • • • Triangle TR688 11R22.5 • • • • • • • • • Triangle TRS01 11R22.5 • Windpower HN08 11R22.5 Windpower HN266 11R22.5 • Windpower WDR23 11R22.5 • Windpower WGC08 11R22.5 TRAILING UNIT TYRES DRIVE TYRES Page 14 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A Declaration I, La s zlo Bruzsa Chief Engineer , delegate of the National Heavy Vehicle Regulator, approve this PBS Vehicle A pproval PBS – V 211212 – VA 10804 Laszlo (Les) Bruzsa Chief Engineer National Heavy Vehicle Regulator D ated : 24/03/22 Revision table N VA Ver s Brief description Date 1 10804 1 A First issue. 24 /03/22 Page 15 of 15 National Heavy Vehicle Regulator www.nhvr.gov.au 201401 - 0067 PBS Vehicle Approval – V 211212 – V A 10804 – v1A Important i nformation As per Heavy Vehicle National Law Section 153, the driver must keep in the driver's possession a copy of this Vehicle Approval and be able to produce it for inspection by compliance officers. Penalties apply. If changes or modifications are required, these are limited to the specifications contained in the relevant PBS Design Approval and the Application for Desig n Approval Part A and B. Contact the applicant (s ee the cover page on this document) for information related to the allowed specifications. A change of components and/or dimensions must be certified by an approved PBS certifier and an updated version of this Vehicle Approval must be obtained. A change of tyres, outside of the list contained on this Vehicle Approval, also requires approval but will not require an inspection by a PBS certifier. Road access This is not an authorisation to access t he road network. You must comply with the relevant Notice or obtain an access permit. Please note tha t if you add vehicles to a PBS V ehicle A pproval you will need to update the access permit to reflect the latest Vehicle Approval . If the new vehicles have different mass es or dimensions to what is already approv ed, the NHVR will have to seek R oad M anager consent again ; which may extend the time required to issue the new permit. For more inform ation on the PBS Truck and Dog Notice visit National C lass 2 PBS level 1 and 2A T ruck and D og T railer A uthorisation N otice 20 2 1. To apply for an access permit, visit the NHVR Portal You must supply a route ID when applying for an access permit. Use Route Planner to obtain your route ID, you can do this as part of the permit applicati on process in the NHVR Portal For further assistance please visit our website at www.nhvr.gov.au or call 13 NHVR (13 64 87 ). For queries relating to this document please contact the PBS Coordinator at pbs@nhvr.gov.au Transfer of Vehicle Approval When applying for an access permit for a PBS vehicle, a PBS Vehicle Approval must be in the nam e of the company that operates the vehicle on the road. If/ when a PBS combination is sold, the PBS Vehicle Approval has to be transferred across to the new owner. To trans fer a PBS Vehicle Approval to a new owner, use a PBS Vehicle Approval Transfer Application form